地热井保温水泥导热系数影响因素研究

张丰琰; 李立鑫; 代晓光; 董子良; 韩丽丽; 王博

doi:10.19912/j.0254-0096.tynxb.2022-0666

PDF(1893 KB)

太阳能学报 ›› 2023, Vol. 44 ›› Issue (9) : 493-502. DOI: 10.19912/j.0254-0096.tynxb.2022-0666

地热井保温水泥导热系数影响因素研究

张丰琰¹, 李立鑫¹, 代晓光², 董子良¹, 韩丽丽¹, 王博¹

作者信息 +

RESEARCH ON INFLUENCING FACTORS OF THERMAL CONDUCTIVITY OF THERMAL INSULATION CEMENT FOR GEOTHERMAL WELL

Zhang Fengyan¹, Li Lixin¹, Dai Xiaoguang², Dong Ziliang¹, Han Lili¹, Wang Bo¹

Author information +

文章历史 +

摘要

选择合适的测试方法探究不同因素对保温水泥导热系数的作用规律和方式。研究表明：随着保温材料加量和水灰比的增大,水泥石导热系数先迅速减小,随后下降速率降低并逐渐趋于稳定;随着养护温度的升高和时间的增长,导热系数逐渐减小,并在7 d后基本稳定;随着含水率的增大和测试温度的升高,导热系数显著增大;其中,含水率、测试温度、保温材料加量和水灰比等因素对导热系数的影响逐级递减。低密度和具有类蜂窝状结构的保温材料在降低导热系数和维持抗压强度等方面具有较大优势,且保温材料的推荐加量为15%~20%。

Abstract

This paper reveals the variation law of thermal conductivity of thermal insulation cement under various factors and the corresponding changes of micro characteristics on the basis of selecting appropriate test methods. The experimental results show that the thermal conductivity first decreases rapidly, and then the decline rate tends to be stable with the increase of the amount of insulation materials and the water cement ratio. The extension of curing time and the increase of curing temperature help to reduce the heat transfer capacity of the skeleton, but the thermal conductivity is basically stable after the curing temperature exceeds 120 ℃ in a same curing time and the curing time exceeds 7 d at a same temperature. And the increase of moisture content and test temperature can significantly improve the thermal conductivity by enhancing the heat transfer capacity of voids and skeletons. What’s more, the results of factor significance analysis show that the effect of moisture content is the most obvious, the test temperature and the amount of insulation material are the second, and the influence of water cement ratio is the lowest. The analysis results show that the low-density thermal insulation material can effectively reduce the thermal conductivity, and the honeycomb like structure has great advantages in maintaining the strength of cement. In addition, cement within 15%-20% thermal insulation material can get better thermal insulation effect on the basis of ensuring reasonable compressive strength and economy.

导出引用

张丰琰, 李立鑫, 代晓光, 董子良, 韩丽丽, 王博. 地热井保温水泥导热系数影响因素研究[J]. 太阳能学报. 2023, 44(9): 493-502 https://doi.org/10.19912/j.0254-0096.tynxb.2022-0666

Zhang Fengyan, Li Lixin, Dai Xiaoguang, Dong Ziliang, Han Lili, Wang Bo. RESEARCH ON INFLUENCING FACTORS OF THERMAL CONDUCTIVITY OF THERMAL INSULATION CEMENT FOR GEOTHERMAL WELL[J]. Acta Energiae Solaris Sinica. 2023, 44(9): 493-502 https://doi.org/10.19912/j.0254-0096.tynxb.2022-0666

中图分类号： P314.9

参考文献

[1] 豆惠萍, 陈新海, 朱萍, 等. 供暖地热开采井筒温度损失模型及应用[J]. 地质与勘探, 2019, 55(5): 1276-1286.
DOU H P, CHEN X H, ZHU P, et al.A model of temperature loss in the wellbore of geothermal exploitation for heating and its application[J]. Geology and exploration,2019, 55(5): 1276-1286.
[2] HASAN A R, KABIR C S.Fluid flow and heat transfer in wellbore[M]. Society of Petroleum Engineers, Texas, 2002.
[3] KANEV K, IKEUCHI J, KIMURA S, et al.Heat loss to the surrounding rock formation from a geothermal wellbore[J]. Geothermics, 1997, 26(2): 329-349.
[4] ZHOU F Z, ZHENG X H.Heat transfer in tubing-casing annulus during production process of geothermal systems[J]. Journal of earth science, 2015, 26(1): 116-123.
[5] 李晓益, 何汉平, 段友智, 等. 砂岩孔隙型地热井提高热效工艺分析[J]. 石油钻采工艺, 2017, 39(4): 484-490.
LI X Y, HE H P, DUAN Y Z, et al.Analysis on the thermal efficiency improvement process for geothermal well in porous sandstone[J]. Oil drilling & production technology, 2017, 39(4): 484-490.
[6] 杨书港. 隔热套管完井工艺设计与现场实践[J]. 石油工业技术监督, 2019, 35(1): 1-4.
YANG S G.Thermal insulation casing completion technology design and field practice[J]. Technology supervision in petroleum industry, 2019, 35(1): 1-4.
[7] 朱明, 段友智, 高小荣, 等. 地热井热损失影响因素敏感性分析[J]. 科技导报, 2015, 33(22): 32-36.
ZHU M, DUAN Y Z, GAO X R, et al.Heat preservation suggestion and heat loss analysis of geothermal well[J]. Science & technology review, 2015, 33(22): 32-36.
[8] 李瑞霞, 王高升, 宋先知, 等. 固井水泥对同轴型换热系统取热效果影响数值分析[J]. 建筑科学, 2018, 34(4): 36-40.
LI R X, WANG G S, SONG X Z, et al.Numerical analysis of the effect of cement sheath on the heat extraction performance of coaxial borehole heat exchangers geothermal system[J]. Building science, 2018, 34(4): 36-40.
[9] WON J, LEE D, NA K, et al.Physical properties of G-class cement for geothermal well cementing in South Korea[J]. Renewable energy, 2015, 80: 123-131.
[10] ICHIM A, TEODORIU C, FALCONE G.Estimation of cement thermal properties through the three-phase model with application to geothermal wells[J]. Energies, 2018, 11(10): 2839.
[11] ICHIM A, TEODORIU C, FALCONE G.Influence of cement thermal properties on wellbore heat exchange:proceedings[C]//41st Workshop on Geothermal Reservoir Engineering. Stanford University,Stanford,California,2016.
[12] JONGMUK W, CHOI H, LEE H, et al.Numerical investigation on the effect of cementing properties on the thermal and mechanical stability of geothermal wells[J]. Energies, 2016,12(9): 1016.
[13] 曾春燕, 张岩, 蒋建强, 等. 试样厚度和温差对模塑板导热系数测试结果的影响[J]. 新型建筑材料, 2019, 46(10): 24-27,78.
ZENG C Y, ZHANG Y, JIANG J Q, et al.Effect of thickness and temperature difference on test results of thermal conductivity of molded plates[J]. New building materials, 2019, 46(10): 24-27, 78.
[14] 曹国举, 宫经伟, 蔺元, 等. 水泥石导热系数影响因素研究[J]. 人民黄河, 2020, 42(2): 94-98, 116.
CAO G J, GONG J W, LIN Y, et al.Research on influence factor of thermal conductivity of cement stone[J]. Yellow river, 2020, 42(2): 94-98, 116.
[15] 王莹莹, 马超, 刘艳峰, 等. 含湿量对混凝土导热系数的影响分析[J]. 建筑材料学报, 2018, 21(4): 595-599.
WANG Y Y, MA C, LIU Y F, et al.Effect of moisture content on thermal conductivity of concretes[J]. Journal of building materials, 2018, 21(4): 595-599.
[16] 杨雨, 徐拴海, 张浩, 等. 填料对地热井固井材料导热性能的影响[J]. 煤田地质与勘探, 2020, 48(5): 182-189.
YANG Y, XU S H, ZHANG H, et al.Effect of thermally conductive filler on thermal conductivity of cementing materials in geothermal wells[J]. Coal geology & exploration, 2020, 48(5): 182-189.
[17] 方姚, 张勇, 冉真真. 中深层地热井固井导热水泥导热系数研究[J]. 材料导报, 2020, 34(20): 20028-20033,20052.
FANG Y, ZHANG Y, RAN Z Z.Thermal conductivity of cementing conductive cement in medium and deep geothermal well[J]. Materials review, 2020, 34(20): 20028-20033, 20052.
[18] SONG X Z, ZHENG R, LI R X, et al.Study on thermal conductivity of cement with thermal conductive materials in geothermal well[J]. Geothermics, 2019, 81: 1-11.
[19] 陈驰, 朱传庆, 唐博宁, 等. 岩石热导率影响因素研究进展[J]. 地球物理学进展, 2020, 35(6): 2047-2057.
CHEN C, ZHU C Q, TANG B N, et al.Progress in the study of the influencing factors of rock thermal conductivity[J]. Progress in geophysics, 2020, 35(6): 2047-2057.
[20] ABDOLHOSSEINI Q M J, ULM F, PELLENQ R J. Physical origins of thermal properties of cement paste[J]. Physical review applied, 2015, 3(6): 064010.
[21] SARKAR P K, MITRA N.Thermal conductivity of cement paste: influence of macro-porosity[J]. Cement and concrete research, 2021, 143: 106385.
[22] 姜自超, 汪宏涛, 戴丰乐, 等. 基于瞬态平面热源法的磷酸镁水泥石导热系数研究[J]. 新型建筑材料, 2017, 44(2): 82-85.
JIANG Z C, WANG H T, DAI F L, et al.Study of thermal conductivity of magnesium phosphate cement paste based on transient plane source method[J]. New building materials, 2017, 44(2): 82-85.
[23] 崔玉理, 贺鸿珠. 温度对泡沫混凝土性能影响[J]. 建筑材料学报, 2015, 18(5): 836-839, 846.
CUI Y L,HE H Z.Influence of temperature on performances of foam concrete[J]. Journal of building materials, 2015, 18(5): 836-839, 846.
[24] 张浩, 徐拴海, 杨雨, 等. 地热井固井材料导热性能影响因素[J]. 煤田地质与勘探, 2020, 48(2): 195-201.
ZHANG H, XU S H, YANG Y, et al.Influencing factors of thermal conductivity of cementing materials for geothermal wells[J]. Coal geology & exploration, 2020, 48(2): 195-201.
[25] 宫经伟, 曹国举, 陈国新, 等. 混凝土导热系数与其饱和度及温度的关系[J]. 水电能源科学, 2017, 35(12): 112-115, 111.
GONG J W, CAO G J, CHEN G X, et al.Relationship between thermal conductivity of concrete and its saturation and temperature[J]. Water resources and power, 2017, 35(12): 112-115, 111.
[26] 石锦炎, 韩丹, 刘嫄春, 等. 不同温度下泡沫混凝土热物理性能的研究[J]. 工程热物理学报, 2020, 41(7): 1719-1727.
SHI J Y, HAN D, LIU Y C, et al.Investigation on thermophysical properties of foamed concrete at different temperatures[J]. Journal of engineering thermophysics, 2020, 41(7): 1719-1727.
[27] ZHAO H T, FAN G C, WEI Z Z, et al.Investigation of thermal conductivity and related parameters of early-age cement paste[J]. International journal of heat and mass transfer, 2020, 155: 119798.
[28] BAGHBAN H M, HOVDE P J, JACOBSEN S.Analytical and experimental study on thermal conductivity of hardened cement pastes[J]. Materials and structures, 2013, 46(9): 1537-1546.
[29] 代丹丹. 超轻发泡水泥保温板孔结构与性能关系的研究[D]. 北京: 北京工业大学材料工程, 2016.
DAI D D.Relationship between the pore structure and the properties of ultralight foamed cement insulation board[D]. Beijing: Beijing University of Technology, 2016.
[30] 张雪, 胡敏, 陈德鹏. 含水率及温度对钢渣泡沫混凝土导热系数的影响[J]. 安徽工业大学学报(自然科学版),2018, 35(2): 104-109.
ZHANG X, HU M, CHEN D P.Effect of water content and temperature on thermal conductivity of steel slag foamed concrete[J]. Journal of Anhui University of Technology(natural science), 2018, 35(2): 104-109.
[31] 张婵韬. 玻化微珠保温砂浆导热系数模型研究[D]. 长沙: 湖南大学, 2014.
ZHANG C T.Study on the thermal conductivity model of hollow microspheress insulating mortar[D]. Changsha:Hunan University, 2014.
[32] 王祥. 基于水泥基的保温隔热墙体材料研究与应用[D]. 淮南: 安徽理工大学, 2010.
WANG X.Research and application of insulated and adiabatic wall materials with cement-based[D]. Huainan: Anhui University of Science & Technology, 2010.
[33] 马超. 多孔建筑材料内部湿分布及湿传递对导热系数影响研究[D]. 西安: 西安建筑科技大学, 2017.
MA C.Research on effect of moisture distribution and transfer on thermal conductivity of porous building materials[D]. Xi’an: Xi’an University of Architecture and Technology, 2017.
[34] 彭小云, 翁达福. 南昌地区保温材料含湿量与导热系数的修正研究[J]. 新型建筑材料, 2019, 46(1): 75-78.
PENG X Y, WENG D F.Study on modification of moisture content and thermal conductivity of thermal insulation materials in Nanchang area[J]. New building materials, 2019, 46(1): 75-78.
[35] 孙立新, 冯驰, 崔雨萌. 温度和含湿量对建筑材料导热系数的影响[J]. 土木建筑与环境工程, 2017, 39(6): 123-128.
SUN L X, FENG C, CUI Y M.Influence of temperature and moisture content on the thermal conductivity of building materials[J]. Journal of civil, architectural & environmental engineering, 2017, 39(6): 123-128.
[36] 石锦炎, 韩丹, 刘嫄春, 等. 不同温度下泡沫混凝土热物理性能的研究[J]. 工程热物理学报, 2020, 41(7): 1719-1727.
SHI J Y, HAN D, LIU Y C, et al.Investigation on thermophysical properties of foamed concrete at different temperatures[J]. Journal of engineering thermophysics, 2020, 41(7): 1719-1727.