为实现太阳能飞行器能源系统的高效率和高功率密度,采用基于氮化镓（GaN）器件的四开关升降压（FSBB）变换器。首先提出一种变移相角控制策略,该控制策略可根据不同的输入电压范围,通过改变移相角来使电感电流纹波始终维持在此时工况下的最小值,同时保证电感以最小电流进行环流并兼顾软开关技术,进一步提高变换器的工作效率。然后对所提控制策略下的变换器进行建模,分析其稳定性,并通过对控制参数进行整定,完成变换器补偿网络的环路设计。最后搭建一台输入30~60 V,输出45 V/200 W的GaN FSBB变换器实验样机,验证变移相角控制策略的有效性。
Abstract
In order to realize the high efficiency and high power density of the solar aircraft energy system, a four-switch Buck-Boost （FSBB） converter based on Gallium Nitride （GaN） devices is used. Firstly, a variable phase-shift angle control strategy is proposed. This control strategy can keep the inductor current ripple at the minimum value under the current operating conditions by changing the phase-shift angle according to the input voltage ranges, and at the same time ensure that the inductor current is circulating at the minimum value and take into account the soft switching technology, and further improve the working efficiency of the converter. Then, is modeled based on the converter under the proposed control strategy and its stability is analyzed. The loop design of the converter compensation network is completed by tuning the control parameters. Finally, an experimental prototype of a GaN-based FSBB converter with an input of 30-60 V and an output of 45 V/200 W was built to verify the effectiveness of the variable phase-shift angle control strategy.
关键词
太阳能飞行器 /
氮化镓 /
太阳能转换 /
DC-DC变换器 /
电感电流纹波 /
控制策略
Key words
solar aircraft /
gallium nitride /
solar energy conversion /
DC-DC converters /
inductor current ripple /
control strategy
{{custom_sec.title}}
{{custom_sec.title}}
{{custom_sec.content}}
参考文献
[1] 呼文韬. 太阳能飞行器太阳能能源系统的设计与实现[D]. 天津: 天津大学, 2013.
HU W T.Design and implementation of power system for solar energy air vehicle[D]. Tianjin: Tianjin University, 2013.
[2] 娄建成. 基于双管Buck-Boost的三相光伏并网系统研究[D]. 大庆: 东北石油大学, 2019.
LOU J C.Research on three-phase photovoltaic grid-connected system based on two-switch Buck-Boost[D].Daqing: Northeast Petroleum University, 2019.
[3] KIM D, LEE B.An enhanced control algorithm for improving the Light-Load efficiency of noninverting synchronous buck-boost converters[J]. IEEE transactions on power electronics, 2016, 31(5): 3395-3399.
[4] JONES D C, ERICKSON R W.A nonlinear state machine for dead zone avoidance and mitigation in a synchronous noninverting Buck-Boost converter[J]. IEEE transactions on power electronics, 2013, 28(1): 467-480.
[5] YAO C, RUAN X B, WANG X H, at al. Isolated Buck-Boost DC/DC converters suitable for wide input-voltage range[J]. IEEE transactions on power electronics, 2011,26(9): 2599-2613.
[6] 任小永, 阮新波, 李明秋, 等. 双沿调制的四开关Buck-Boost变换器[J]. 中国电机工程学报, 2009, 29(12): 16-23.
REN X Y, RUAN X B, LI M Q, at al. Dual edge modulated four-switch Buck-Boost converter[J]. Proceedings of the CSEE, 2009, 29(12): 16-23.
[7] YU Z, KAPELS H, HOFFMAN K F.Extreme high efficiency non-inverting Buck-Boost converter for energy storage systems[C]//International Exhibition and Conference for Power Electronics, Intelligent Motion, Renewable Energy and Energy Management. Nuremberg, Germany, 2016: 1-8.
[8] WANG Y, LAN J Y, HUANG X, at al. An improved single-mode control strategy based on four-switch Buck-Boost converter[C]//2020 IEEE Applied Power Electronics Conference and Exposition (APEC), New Orleans, LA, USA, 2020: 320-325.
[9] 姚川. 适用于宽输入电压范围的Buck-Boost直流变换器及其控制策略的研究[D]. 武汉: 华中科技大学, 2013.
YAO C.Buck-Boost converter suitable for wide input voltage range: topologies and control strategies[D]. Wuhan: Huazhong University of Science and Technology, 2013.
[10] LIU Y, JIANG Y, HUA G C.A self-driven synchronous rectification scheme for low output switching-mode converter[C]//The 4th International Power Electronics and Motion Control Conference. Xi’an, China, 2004: 1166-1169.
[11] ZHOU Z J, LI H Y, WU X K.A constant frequency ZVS control system for the four-switch Buck-Boost DC-DC converter with reduced inductor current[J]. IEEE transactions on power electronics, 2019, 34(7): 5996-6003.
[12] ERICKSON R W, MAKSIMOVIĆ D.Fundamentals of power electronics[M]. Third Edition. Netherlands: Springer 1997.
[13] DIXON L.Average current mode control of switching power supplies[R]. Unitrode Product & Applications Handbook, 1990.
基金
国家自然科学基金面上项目（51877007）
PDF(2420 KB)
