海拔高度对质子交换膜燃料电池堆的性能影响

张瞳; 夏玉珍; 张丽; 胡桂林

doi:10.19912/j.0254-0096.tynxb.2025-0123

PDF(2187 KB)

太阳能学报 ›› 2026, Vol. 47 ›› Issue (6) : 586-593. DOI: 10.19912/j.0254-0096.tynxb.2025-0123

海拔高度对质子交换膜燃料电池堆的性能影响

张瞳, 夏玉珍, 张丽, 胡桂林

作者信息 +

IMPACT OF ALTITUDE ON PERFORMANCE OF PROTON EXCHANGE MEMBRANE FUEL CELL STACKS

Zhang Tong, Xia Yuzhen, Zhang Li, Hu Guilin

Author information +

文章历史 +

摘要

在ANSYS/Fluent软件中建立全尺度的小型空冷型质子交换膜燃料电池（PEMFC）堆仿真模型,并采用计算流体力学（CFD）方法进行求解。研究不同海拔高度和阴极过量系数对电池堆的输出性能、温度和氧气浓度的影响。结果表明：海拔升高到3200 m时,电池堆的峰值功率密度降低了21.6%;增加阴极过量系数可补偿因海拔升高而降低的氧气浓度,提高电池堆的输出性能,减小电池堆的内部温度差异。

Abstract

A full-scale simulation model of a small air-cooled PEMFC stack is established in ANSYS/Fluent software, and the solution is obtained using computational fluid dynamics （CFD） methods. The effects of different altitudes and cathode stoichiometric ratios on the output performance, temperature, and oxygen concentration of the fuel cell stack are investigated. The results indicate that when the altitude increases to 3200 m, the peak power density of the fuel cell stack decreases by 21.6%. Increasing the cathode stoichiometric ratio can compensate for the decrease in oxygen concentration caused by higher altitudes, improve the output performance of the fuel cell stack and reduce the internal temperature differences within the stack.

导出引用

张瞳, 夏玉珍, 张丽, 胡桂林. 海拔高度对质子交换膜燃料电池堆的性能影响[J]. 太阳能学报. 2026, 47(6): 586-593 https://doi.org/10.19912/j.0254-0096.tynxb.2025-0123

Zhang Tong, Xia Yuzhen, Zhang Li, Hu Guilin. IMPACT OF ALTITUDE ON PERFORMANCE OF PROTON EXCHANGE MEMBRANE FUEL CELL STACKS[J]. Acta Energiae Solaris Sinica. 2026, 47(6): 586-593 https://doi.org/10.19912/j.0254-0096.tynxb.2025-0123

中图分类号： TM911.4

参考文献

[1] 陈家城, 周苏. 大功率质子交换膜燃料电池建模及仿真[J]. 太阳能学报, 2024, 45(3): 290-297.
CHEN J C, ZHOU S.Modeling and simulation of high-power proton exchange membrane fuel cells[J]. Acta energiae solaris sinica, 2024, 45(3): 290-297.
[2] DIMITROVA Z, BOU NADER W.PEM fuel cell as an auxiliary power unit for range extended hybrid electric vehicles[J]. Energy, 2022, 239: 121933.
[3] GONG A, VERSTRAETE D.Fuel cell propulsion in small fixed-wing unmanned aerial vehicles: current status and research needs[J]. International journal of hydrogen energy, 2017, 42(33): 21311-21333.
[4] 刘宗巍, 史天泽, 郝瀚, 等. 中国燃料电池汽车发展问题研究[J]. 汽车技术, 2018(1): 1-9.
LIU Z W, SHI T Z, HAO H, et al.Research on main problems associated with development of fuel cell vehicle in China[J]. Automobile technology, 2018(1): 1-9.
[5] SONG W J, CHEN H, GUO H, et al.Research progress of proton exchange membrane fuel cells utilizing in high altitude environments[J]. International journal of hydrogen energy, 2022, 47(59): 24945-24962.
[6] 樊智鑫, 宋珂, 章桐. 空冷质子交换膜燃料电池性能优化研究综述[J]. 汽车技术, 2020(4): 1-8.
FAN Z X, SONG K, ZHANG T.A review on performance optimization of air-cooled proton exchange membrane fuel cell[J]. Automobile technology, 2020(4): 1-8.
[7] ZHANG J K, WANG C J, ZHANG A F.Experimental study on temperature and performance of an open-cathode PEMFC stack under thermal radiation environment[J]. Applied energy, 2022, 311: 118646.
[8] GONG C Y, XING L, LIANG C, et al.Modeling and dynamic characteristic simulation of air-cooled proton exchange membrane fuel cell stack for unmanned aerial vehicle[J]. Renewable energy, 2022, 188: 1094-1104.
[9] HORDÉ T, ACHARD P, METKEMEIJER R.PEMFC application for aviation: experimental and numerical study of sensitivity to altitude[J]. International journal of hydrogen energy, 2012, 37(14): 10818-10829.
[10] UNO M, SHIMADA T, ARIYAMA Y, et al.Development and demonstration flight of a fuel cell system for high-altitude balloons[J]. Journal of power sources, 2009, 193(2): 788-796.
[11] GONZÁLEZ-ESPASANDÍN Ó, LEO T J, RASO M A, et al. Direct methanol fuel cell (DMFC) and H₂ proton exchange membrane fuel (PEMFC/H₂) cell performance under atmospheric flight conditions of Unmanned Aerial Vehicles[J]. Renewable energy, 2019, 130: 762-773.
[12] JIANG F F, WEI Z B, ZHANG C Z, et al.Cathodic supply optimization of PEMFC system under variable altitude[J]. IEEE transactions on industrial electronics, 2024, 71(11): 14298-14307.
[13] 苗宇航, 邢路, 程文君, 等. 空冷型PEMFC高海拔地区运行特性研究[J]. 电源技术, 2021, 45(8): 1023-1026.
MIAO Y H, XING L, CHENG W J, et al.Study on operation characteristics of air-cooled PEMFC in high altitude area[J]. Chinese journal of power sources, 2021, 45(8): 1023-1026.
[14] 胡祎玮, 夏玉珍, 陆佳宙, 等. 基于计算流体力学的大型质子交换膜燃料电池电堆歧管尺寸优化分析[J]. 汽车技术, 2022(6): 20-26.
HU Y W, XIA Y Z, LU J Z, et al.Optimization analysis of manifold dimension of large PEMFC stack based on CFD[J]. Automobile technology, 2022(6): 20-26.
[15] ZHANG Y, HE S R, JIANG X H, et al.Full-scale three-dimensional simulation of air cooling metal bipolar plate proton exchange membrane fuel cell stack considering a non-isothermal multiphase model[J]. Applied energy, 2024, 357: 122507.
[16] 赵杰, 李文浩, 杜常清, 等. 不同操作和环境条件下的PEMFC低温冷启动数值模拟研究[J]. 太阳能学报, 2022, 43(6): 460-466.
ZHAO J, LI W H, DU C Q, et al.Numerical simulation study of low temperature cold start of PEMFC under different operating and environmental conditions[J]. Acta energiae solaris sinica, 2022, 43(6): 460-466.
[17] YU X X, CHANG H W, ZHAO J J, et al.Effects of anode flow channel on performance of air-cooled proton exchange membrane fuel cell[J]. Energy reports, 2022, 8: 4443-4452.
[18] 彭明, 夏强峰, 蒋理想, 等. 阴极过量系数与流场布置对风冷燃料电池性能影响的数值模拟[J]. 化工学报, 2023, 74(10): 4267-4276.
PENG M, XIA Q F, JIANG L X, et al.Numerical simulation on the effect of cathode stoichiometric ratio and flow field arrangement on the performance of air-cooled fuel cells[J]. CIESC journal, 2023, 74(10): 4267-4276.