沙尘颗粒影响翼型气动特性的实验研究

马高生; 王旭哲; 王燕; 孔令埵; 骆冯洋

doi:10.19912/j.0254-0096.tynxb.2025-0445

PDF(13212 KB)

太阳能学报 ›› 2026, Vol. 47 ›› Issue (9) : 662-671. DOI: 10.19912/j.0254-0096.tynxb.2025-0445

沙尘颗粒影响翼型气动特性的实验研究

马高生^1,2, 王旭哲¹, 王燕^1,2, 孔令埵¹, 骆冯洋¹

作者信息 +

EXPERIMENTAL STUDY ON EFFECT OF DUST PARTICLES ON AERODYNAMIC CHARACTERISTICS OF AIRFOILS

Ma Gaosheng^1,2, Wang Xuzhe¹, Wang Yan^1,2, Kong Lingduo¹, Luo Fengyang¹

Author information +

文章历史 +

摘要

依托风洞实验针对风沙环境中风力机翼型S809的气动性能展开研究,分析不同颗粒粒径斯托克斯数（St）和沙尘浓度条件下的升/阻力系数变化、流场特征及沙尘颗粒的动力学行为。实验结果表明：1）不同St工况下升力系数随St的增大呈先增大后减小的趋势,阻力系数缓慢上升;20°与24°攻角下随St的增大速度分布逐步增强,涡结构发生改变,且分离点随St的增大向尾缘迁移;2）不同沙尘浓度条件下在攻角20°~28°范围中升力系数随沙尘浓度的增大而增大。沙尘浓度的增大使得吸力面速度降低,20°与24°攻角下分离点随浓度的增大向前缘移动;3）沙尘浓度的增大导致颗粒聚集现象逐渐向翼型尾缘区域转移;St增大导致沙尘颗粒在翼型分离涡区域数量减小;对比不同攻角下的颗粒分布特征,攻角增大使得沙尘颗粒逐渐在翼型前缘聚集。

Abstract

The study of aerodynamic characteristics for airfoils in sand-laden environments predominantly employs numerical simulation methods, yet inconsistencies in models and assumptions during simulations have led to divergent conclusions regarding sand particle effects on airfoil performance. This paper experimentally investigates the aerodynamic behavior of the S809 wind turbine airfoil in sandy conditions through wind tunnel testing, focusing on lift/drag coefficient variations, flow field patterns, and particle dynamics under different sand particle sizes （characterized by Stokes number, St） and concentration levels. Key experimental findings reveal： 1） Under varying St conditions, the lift coefficient initially increases then decreases with rising St values while the drag coefficient shows gradual growth; at 20° and 24° angles of attack, enhanced velocity distribution emerges with increasing St, accompanied by modified vortex structures and downstream migration of separation points toward the trailing edge. 2） Within the 20°-28° angle of attack range, lift coefficients exhibit a positive correlation with dust concentration under varied concentration conditions, while elevated concentrations reduce suction surface velocity and drive upstream displacement of separation points toward the leading edge at 20° and 24° angles of attack. 3） Higher dust concentrations shift particle accumulation toward the airfoil’s trailing edge region, whereas increased St values reduce particle density within vortex separation zones; comparative analysis of particle distribution across attack angles demonstrates that steeper angles progressively concentrate sand particles near the airfoil’s leading edge.

导出引用

马高生, 王旭哲, 王燕, 孔令埵, 骆冯洋. 沙尘颗粒影响翼型气动特性的实验研究[J]. 太阳能学报. 2026, 47(9): 662-671 https://doi.org/10.19912/j.0254-0096.tynxb.2025-0445

Ma Gaosheng, Wang Xuzhe, Wang Yan, Kong Lingduo, Luo Fengyang. EXPERIMENTAL STUDY ON EFFECT OF DUST PARTICLES ON AERODYNAMIC CHARACTERISTICS OF AIRFOILS[J]. Acta Energiae Solaris Sinica. 2026, 47(9): 662-671 https://doi.org/10.19912/j.0254-0096.tynxb.2025-0445

中图分类号： TK83

参考文献

[1] 王芳. 2026年中国风能新春茶话会在京举办[J]. 风能, 2026(2):18-23.
Wang F.2026 China wind energy New Year Tea Party held in Beijing[J]. Wind Energy, 2026(2):18-23.
[2] 张凌云. 无限“风光”在西部[J]. 新西部, 2021(11): 33-35.
Zhang L Y.Infinite’wind and solar’potential in the western region[J]. New West, 2021, (11): 33-35.
[3] 赵紫原, 白歌. “风光”大基地建设持续升温[J]. 中国电力企业管理, 2023(18): 32-33.
Zhao Z Y, Bai G.The construction of “scenery” base continues to heat up[J]. China Power Enterprise Management, 2023(18): 32-33.
[4] 刘雄飞, 李秋燕, 尹彤. 风力机叶片的气固两相边界层特性数值模拟研究[J]. 太阳能学报, 2021, 42(4): 487-492.
Liu X F, Li Q Y, Yin T.Study on characteristics of gas-solid two-phase boundary layer of wind turbine blades[J]. Acta Energiae Solaris Sinica, 2021, 42(4): 487-492.
[5] Douvi D, Douvi E, Margaris D.Aerodynamic performance of a horizontal axis wind turbine operating with dust: a computational study[J]. Inventions, 2023, 8(1): 3.
[6] 王凯. 风沙环境下1.5 MW风力机叶片气动特性与磨损分析研究[D]. 包头: 内蒙古科技大学, 2022.
Wang K.Analysis and research on aerodynamic characteristics and wear of 1.5 MW wind turbine blades in wind and sand environment[D]. Baotou: Inner Mongolia University of Science & Technology, 2022.
[7] Bouhelal A, Guerri O, Smaili A, et al.Contribution to the aerodynamic study of the air-sand flow around a wind turbine blade installed in desert environment of Algeria[C]//2018 International Conference on Wind Energy and Applications in Algeria (ICWEAA). Algiers, Algeria, 2019: 1-6.
[8] Gao F, Wu X J, Liu Q, et al.Fault simulation and online diagnosis of blade damage of large-scale wind turbines[J]. Energies, 2019, 12(3): 522.
[9] Li D S, Zhao Z X, Li Y R, et al.Effects of the particle Stokes number on wind turbine airfoil erosion[J]. Applied Mathematics and Mechanics (english edition), 2018, 39(5): 639-652.
[10] 李德顺, 胡智豪, 赵慧廷, 等. 前缘圆柱对风力机翼型气动性能及冲蚀磨损影响研究[J]. 太阳能学报, 2024, 45(4): 166-173.
Li D S, Hu Z H, Zhao H T, et al.Investigation on effect of leading edge cylinder on aerodynamic performance and erosion wear of wind turbine arifoil[J]. Acta Energiae Solaris Sinica, 2024, 45(4): 166-173.
[11] Li Y R, Chen F Y, Li R N, et al.Research on aerodynamic characteristics of wind turbine airfoil and blade in sand-wind environment[J]. International Transactions on Electrical Energy Systems, 2021, 31(11): e12541.
[12] 范向增. 风沙环境下水平轴风力机的气动特性研究[D]. 兰州: 兰州理工大学, 2014.
Fan X Z.Research on aerodynamic characteristics of horizontal-axis wind turbine under sand-wind environment[D]. Lanzhou: Lanzhou University of Technology, 2014.
[13] Wang Q, Yu M Y, Li D S, et al.Dynamic stall characteristics of wind turbine airfoil in sand-wind environment[J]. Ocean Engineering, 2023, 274: 114080.
[14] 李德顺, 何婷, 王清. 颗粒直径对风力机翼型动态失速特性的影响研究[J]. 太阳能学报, 2023, 44(12): 207-213.
Li D S, He T, Wang Q.Influence of particle diameter on dynamic stall characteristics of wind turbine airfoil[J]. Acta Energiae Solaris Sinica, 2023, 44(12): 207-213.
[15] Jin J J, Lu Z L, Guo T Q, et al.Marking function of Stokes number on airfoils’ aerodynamic penalties in a gas-solid flow[J]. IET Renewable Power Generation, 2021, 15(16): 3856-3872.
[16] Douvi D C, Margaris D P, Davaris A E.Aerodynamic performance of a NREL S809 airfoil in an air-sand particle two-phase flow[J]. Computation, 2017, 5(1): 13.
[17] Chen S Y, Agarwal R.Numerical investigation of wind turbine airfoils under clean and dusty air conditions[C]//AIAA Aviation 2020 Forum. Reno, Nevada, USA: AIAA, 2020.
[18] Guo T Q, Jin J J, Lu Z L, et al.Aerodynamic sensitivity analysis for a wind turbine airfoil in an air-particle two-phase flow[J]. Applied Sciences, 2019, 9(18): 3909.
[19] Tsuji Y, Kawaguchi T, Tanaka T.Discrete particle simulation of two-dimensional fluidized bed[J]. Powder Technology, 1993, 77(1): 79-87.
[20] Van Wachem B G M, Schouten J C, Van Den Bleek C M, et al. Comparative analysis of CFD models of dense gas-solid systems[J]. AIChE Journal, 2001, 47(5): 1035-1051.
[21] Zhu H P, Zhou Z Y, Yang R Y, et al.Discrete particle simulation of particulate systems: a review of major applications and findings[J]. Chemical Engineering Science, 2008, 63(23): 5728-5770.
[22] Butterfield C P, Musial W P, Simms D A, et al. Combined experiment Phase I: final report[R]. Golden, Colorado, USA: National Renewable Energy Laboratory, 1992. NREL/TP-257-4655.
[23] Song Z X, Wang J Y, Wang S G. Quantitative classification of northeast Asian dust events[J]. Journal of Geophysical Research: Atmospheres, 2007, 112(D4): 2006JD007048.
[24] 李银然, 金俊俊, 韩伟, 等. 不同直径颗粒在S809翼型流场中的运动特性及对其气动性能的影响[J]. 太阳能学报, 2018, 39(10): 2923-2928.
Li Y R, Jin J J, Han W, et al.Motion characteristics of different diameter particles in flow field of S809 airfoil and effect on its aerodynamic performance[J]. Acta Energiae Solaris Sinica, 2018, 39(10): 2923-2928.
[25] Squires K D, Eaton J K.Particle response and turbulence modification in isotropic turbulence[J]. Physics of Fluids a: Fluid Dynamics, 1990, 2(7): 1191-1203.
[26] 张书斌, 陈占秀, 杨历, 等. 绕流圆柱对气固两相流场颗粒聚并效果的研究[J]. 节能, 2016, 35(11): 24-28.
Zhang S B, Chen Z X, Yang L, et al.Study on the effect of particle aggregation in gas solid two phase flow field around a circular cylinder[J]. Energy Conservation, 2016, 35(11): 24-28.
[27] 罗坤, 陈松, 蔡丹云, 等. 气固两相圆柱绕流近场特性的实验研究[J]. 中国电机工程学报, 2006, 26(24): 116-120.
Luo K, Chen S, Cai D Y, et al.Experimental study of flow characteristics in the near field of gas-solid two-phase circular cylinder wakes[J]. Proceedings of the CSEE, 2006, 26(24): 116-120.
[28] Gore R A, Crowe C T.Effect of particle size on modulating turbulent intensity[J]. International Journal of Multiphase Flow, 1989, 15(2): 279-285.
[29] Kussin J, Sommerfeld M.Experimental studies on particle behaviour and turbulence modification in horizontal channel flow with different wall roughness[J]. Experiments in Fluids, 2002, 33(1): 143-159.
[30] 余牧遥. 风沙环境下风力机翼型动态失速特性及磨损研究[D]. 兰州: 兰州理工大学, 2022.
Yu M Y.Aerodynamic and erosion characteristics of wind turbine airfoil during dynamic stall in sand-wind environment[D]. Lanzhou: Lanzhou University of Technology, 2022.
[31] 何婷. 风沙环境下风力机翼型动态失速特性研究[D]. 兰州: 兰州理工大学, 2020.
He T.Study the dynamic stall characteristics of wind turbin airfoil under sand-wind environment[D]. Lanzhou: Lanzhou University of Technology, 2020.
[32] Douvi D C, Douvi E C, Margaris D P.Computational study of NACA 0012 airfoil in air-sand particle two-phase flow at Reynolds number of Re=1.76×10⁶[J]. International Journal of New Technology and Research, 2019, 5(4): 101-108.