为阐明对旋双风轮风力机前后风轮之间的载荷影响规律,基于风洞实验,测量对旋双风轮风力机3个正交方向的力和力矩,研究前后风轮间距和叶尖速比对载荷特性的影响规律。研究发现：高叶尖速比时,单风轮偏航力矩存在明显波动,而对旋双风轮风力机偏航力矩减小,且波动减弱;对旋双风轮风力机间距的变化影响前后风轮所承受的载荷占比,后风轮载荷占比随间距的增大而减小,这是由前后风轮之间所产生复杂的流动及湍流结构所致;虽然前后风轮的推力Fx和倾覆力矩My随叶尖速比的增大均有一定减小,但前后风轮的倾覆力矩Mx和偏航力矩Mz的方向相反,表明对旋双风轮风力机的前后风轮具有一定抵消倾覆力矩和偏航力矩的作用。
Abstract
In order to elucidate the load influence law between the front and rear wind turbines of a counter-rotating twin-wind turbine, the paper is based on wind tunnel experiments to measure the forces and moments in three orthogonal directions of a counter-rotating twin-wind turbine, and to study the influence law of the front and rear wind turbine spacing and the tip speed ratio on the load characteristics. It is found that the yaw moment of the single wind turbine fluctuates significantly at high tip speed ratios, while the yaw moment of the counter-rotating twin-wheel wind turbine decreases and the fluctuation is weakened; the change of the pitch of the counter-rotating twin-wheel wind turbine affects the load share of the front and rear wind turbines, and the load share of the rear wind turbine decreases with the increase of the pitch, which is due to the complex flow and turbulence structure generated between the front and rear wind turbines; the thrust of the front and rear wind turbines, the tilting Although the tilting moment of the front and rear wind turbines decreases with the increase of the tip speed ratio, the tilting moment and yawing moment of the front and rear wind turbines are in opposite directions, which indicates that the front and rear wind turbines of the counter-rotating dual-wind turbine have the effect of counteracting the tilting moment and yawing moment to a certain extent.
关键词
风力机 /
风洞实验 /
气动载荷 /
叶尖速比 /
双风轮风力机
Key words
wind turbine /
wind tunnel experiment /
aerodynamic load /
tip speed ratio /
double-turbine wind turbine
{{custom_sec.title}}
{{custom_sec.title}}
{{custom_sec.content}}
参考文献
[1] ROSENBERG A, SELVARAJ S, SHARMA A.A novel dual-rotor turbine for increased wind energy capture[J]. Journal of physics: conference series, 2014, 524: 012078.
[2] NEWMAN B G.Actuator-disc theory for vertical-axis wind turbines[J]. Journal of wind engineering and industrial aerodynamics, 1983, 15(1/2/3): 347-355.
[3] WANG Z Y, TIAN W, OZBAY A, et al.An experimental study on the aeromechanics and wake characteristics of a novel twin-rotor wind turbine in a turbulent boundary layer flow[J]. Experiments in fluids, 2016, 57(9): 133-150.
[4] 周云龙, 杨承志, 李律万. 新型双风轮风力机气动特性的三维流场数值模拟[J]. 动力工程学报, 2012, 32(9):698-704.
ZHOU Y L, YANG C Z, LI L W.3D flow field numerical simulation on aerodynamic characteristics of new double-rotor wind turbines[J]. Journal of Chinese Society of Power Engineering, 2012, 32(9): 698-704.
[5] 吕金桥. 新型双风轮风力发电风力机建模与控制策略研究[D]. 天津: 河北工业大学, 2015.
LYU J Q.Research on model establishment and control strategy of the new double-rotor wind turbine[D]. Tianjin: Hebei University of Technology, 2015.
[6] KANEMOTO T, GALAL A M.Development of intelligent wind turbine generator with tandem wind rotors and double rotational armatures (1st report, superior operation of tandem wind rotors)[J]. JSME international journal series B fluids and thermal engineering, 2006, 49(2): 450-457.
[7] KOEHUAN V A, SUGIYONO, KAMAL S.Investigation of counter-rotating wind turbine performance using computational fluid dynamics simulation[C]//IOP Conference Series: Materials Science and Engineering, International Conference of Applied Science and Techndogy for Infrastructure Engineering, 5 August 2017. Surabaya, East Java, Indonesia, 2017, 267: 012034.
[8] TIAN W, OZBAY A, HU H.A wind tunnel study of wind loads on a model wind turbine in atmospheric boundary layer winds[J]. Journal of fluids and structures, 2019, 85:17-26.
[9] 张旭耀, 杨从新, 金锐, 等. 低空急流条件下水平轴风力机风轮气动特性的研究[J]. 太阳能学报, 2021, 42(3): 1-8.
ZHANG X Y, YANG C X, JIN R, et al.Study on aerodynamic characteristics of horizontal axis wind turbine under low-level jet inflow condition[J]. Acta energiae solaris sinica, 2021, 42(3): 1-8.
[10] WANG Z Y, OZBAY A, TIAN W, et al.An experimental study on the aerodynamic performances and wake characteristics of an innovative dual-rotor wind turbine[J]. Energy, 2018, 147: 94-109.
[11] OZBAY A, TIAN W, HU H.Experimental investigation on the wake characteristics and aeromechanics of dual-rotor wind turbines[J]. Journal of engineering for gas turbines and power, 2016, 138(4): 042602.
[12] FUJISAWA N, GOTOH F.Experimental study on the aerodynamic performance of a savonius rotor[J]. Journal of solar energy engineering, 1994, 116(3): 148-152.
[13] HUI H, TIAN W, WANG Z Y. An experimental study on the wake characteristics of dual-rotor wind turbines by using a stereoscopic PIV technique[C]//Proceedings of the 34th AIAA Applied Aerodynamics Conference. Washington D C, 2016: AIAA2016-3128.
[14] HU H, WANG Z Y, OZBAY A, et al.An experimental investigation on the wake characteristics behind a novel twin-rotor wind turbine[C]//33rd Wind Energy Symposium. Kissimmee, Florida, 2015.
[15] 李金, 袁巍. 对转风力机的设计及流场数值模拟[J]. 流体机械, 2013, 41(5): 22-28.
LI J, YUAN W.Design and numerical simulation of a counter-rotating wind turbine[J]. Fluid machinery, 2013, 41(5):22-28.
[16] 郭俊凯, 瞿沐淋, 王伟, 等. 多载荷共同作用对大型风力机关键部件受力影响分析[J]. 风机技术, 2021, 63(3): 56-66.
GUO J K, QU M L, WANG W, et al.Analysis on the influence of multiple loads on key components of large wind turbine[J]. Chinese journal of turbomachinery, 2021, 63(3): 56-66.
基金
国家自然科学基金（52166014）; 甘肃省基础研究创新群体项目（21JR7RA277）; 兰州理工大学红柳杰出青年人才资助计划; 甘肃省科技计划（20JR5RA445）
PDF(2037 KB)
